Product ID:1 B 15 H AEROSOL
MSDS Date:06/17/1991
FSC:5970
NIIN:00-990-4924
MSDS Number: BHXCR

HUMISEAL DIVISION/CHASE CORPORATION

26-60 BROOKLYN/QUEENS EXPRESSWAY WEST
WOODSIDE, NY 11377-0445
US

Emergency Phone: 718-932-0800

Info Phone: 718-932-0800/FAX -4345

Cage: HUMIS

HUMISEAL DIVISION/CHASE CORPORATION

WOODSIDE, NY 11377 US

Telephone: 718-932-0800

Cage: 99109

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 30-39%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 18-23%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 8-12%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PROPANE

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15-20%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT; 9192

BUTANE

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 15-20%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM; 9192

ACRYLIC POLYMER

Fraction By Weight: 10-15%

LD50 LC50 Mixture:ORAL LD50 (RAT) IS 5,000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-MAY CAUSE IRRITATION,CORNEAL
BURNS.SKIN;PROLONGED/REPEATED CONTACT CAN CAUSE
DEFATTING,DRYING,IRRITATION & DERMATITIS.INHALE:CAUSES CNS
DEPRESSION.MAY CAUSE DIZZINESS,HEADACHE,NAUSEA.>1000 PPM M AY CAUSE
CONVULSION & DEATH.ORAL:SIMILARTO INHALE.POSE ASPIRATION
HAZARD.CHRONIC-MAY CAUSE DEFATTING & DERMATITIS.
Effects of Overexposure:MAY CAUSE IRRITATION, CORNEAL BURNS. PROLONGED
OR REPEATED SKIN CONTACT CAN CAUSE DEFATTING, DRYING, IRRITATION &
DERMATITIS. INHALATION CAUSES CNS DEPRESSION. MAY CAUSE DIZZINESS,
HEADACHE, NAUSEA. I F GREATER THAN 1000 PPM, MAY CAUSE CONVULSION &
DEATH. ORAL HAS SYMPTOMS SIMILAR TO INHALE. POSE ASPIRATION HAZARD.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO THIS MATERIAL.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.SKIN:WASH WITH SOAP
& WATER.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED.ORAL:DO NOT IN DUCE VOMITING.GET MEDICAL ATTENTION
IMMEDIATELY.NOTE TO PHYSICIAN:IF >2 ML/KG HAS BEEN INGESTED & NO
VOMITING,EMESIS SHOULD BE INDUCED.IF UNCONSCIOUS/CONVULSION
OCCURS,GASTRIC LAVAGE SHOULD BE DONE.

Flash Point Method:TOC
Flash Point:FLAMMABL AEROSOL
Extinguishing Media:CARBON DIOXIDE, FOAM OR DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE AND RELEASE
FLAMMABLE LIQUIDS AND/OR GASES IF EXPOSED TO HEAT ABOVE 120F.
VAPORS HEAVIER THAN AIR. CAN TRAVEL TO IGNITION SOURCE & IGNITE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILLS WITH INERT ABSORBENT
MATERIAL (SAND, VERMICULITE, ETC.). PLACE IN CONTAINERS. PREVENT
ENTERING WATERWAYS/SEWERS .

Handling and Storage Precautions:STORAGE- KEEP AWAY FROM HEAT, SPARKS &
OPEN FLAMES. STORE AT AMBIENT TEMPERATURE. GROUND TO PROTECT FROM
STATIC CHARGE.
Other Precautions:AVOID EXCESSIVE INHALATION. DO NOT INCINERATE OR
PUNCTURE CONTAINERS, EVEN WHEN EMPTY. WASH THOROUGHLY AFTER
HANDLING. KEEP AWAY FROM REACH OF CHILDREN. KEEP CONTAINER CLOSED.
USE ADEQUATE VENTILATIO N.

Respiratory Protection:NIOSH-APPROVED ORGANIC-VAPOR RESPIRATOR OR
SELF-CONTAINED BREATHING APPARATUS IF TLV IS EXCEEDED.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:IMPERVIOUS
Eye Protection:CHEMICAL TYPE GOGGLES
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:USE ONLY AS DIRECTED ON LABEL. READ LABEL
BEFORE USING PRODUCT.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A OR B, UNDER THE
SAME NSN.

HCC:V3
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER CLEAR, LOW VISCOSITY LIQUID, AROMATIC ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, DIRECT SUNLIGHT,
TEMPERATURES ABOVE 120F, SPARKS, HOT SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.